新闻动态
新闻动态 当前位置:首页>新闻动态>新闻动态

中频炉安全运作

网址:www.bddianlu.com.cn  2019-06-03  作者:admin    阅读:

中频炉安全运作
Safe Operation of IF Furnace
一、开炉前的注意事项
I. Notices before the start-up of the furnace
中频电炉在开炉前必需要对电气设备、水冷却系统、感应器铜管等进行检查,只有在这几个设备完好的情况下才能开炉,确保热处理的安全性,否则禁止开炉;确定专门负责送电和开炉的人员,并且负责人员不得擅自离开岗位,工作期间必需对感应器和坩埚的外部情况进行监管,以防止有人在送电后触碰感应器和电缆,影响中频电炉的正常作业或发生安全意外。
Medium frequency electric furnace must check electrical equipment, water cooling system, copper tube of inductor before starting the furnace. Only when these equipments are in good condition can it start www.mashengchang.com www.futejixie.com www.yiwenmenye.com www.juanlianmen58.com 7 www.yuanshengmenye.com www.zhigongyiyuan.com.cnthe furnace to ensure the safety of heat treatment, otherwise it is forbidden to start the furnace. The personnel in charge of power supply and starting the furnace should be determined, and the personnel in charge should not leave their posts without authorization. During the working period, the external conditions of inductor and crucible must be checked. Conditions should be monitored to prevent people from touching sensors and cables after power transmission, affecting the normal operation of medium frequency electric furnaces or causing safety accidents.
二、开炉后的注意事项
II. Notices after Boiling-in
中频电炉开炉后,在进行装料时,应对炉料内进行检查,避免混入易燃易爆等有害物品。为了防止结盖现象的出现,严禁在钢液中直接加入冷料和湿料,以及在熔化液充满到上部后不得加入体积较大的块料;为避免出现爆炸意外,必需确保浇注场地和炉前地坑无积水,无障碍物;而在进行浇注时需两人配合进行,而剩余的钢液只能倒在在制定地点,不能随处乱倒。
After the medium frequency electric furnace is opened, when charging, the charge should be inspected to avoid mixing inflammable and explosive harmful substances. In order to prevent the phenomenon of capping, it is strictly forbidden to add cold and wet materials directly into molten steel, and not to add larger bulk materials after the melting liquid fills the upper part; in order to avoid explosion accidents, it is necessary to ensure that there is no water accumulation and barrier-free in the pouring site and the pit in front of the furnace; while in pouring, it is necessary for two people to cooperate, and the remaining molten steel can only be poured at the designated site, not at the designated site. Everywhere in disorder.
三、维护保养时的注意事项
3. Notices in Maintenance
在对中频电炉进行维护保养时,应保持中频发电机房内的清洁,严禁易燃易爆的物品堆放。对熔损过度的炉膛及时进行修补,在补炉时要避免铁屑、氧化铁混入,保证坩埚的密实。
When maintaining the medium frequency electric furnace, it is necessary to keep the room clean and prohibit the stacking of inflammable and explosive materials. The furnace with excessive melting loss should be repaired in time, so as to avoid the mixing of iron chips and iron oxide and ensure the compactness of the crucible.

联系电话
13051110666